排烟罩和前端油烟净化器的清洗方法
Cleaning method for smoke exhaust hood and front end oil fume purifier
油烟进化器排烟罩和前端油烟净化器一般是设置为一体的。
The smoke exhaust hood and front end smoke purifier are generally integrated.
部件：烟罩包含罩体和罩盖、防爆灯，前端净化器包括UV灯、川铁油网、运水烟罩等。
Components: The smoke hood includes the cover body and cover, explosion-proof light, and the front-end purifier includes UV light, Chuantie oil screen, and water smoke hood.
清洗方法：防爆灯、UV灯可以经常用湿抹布擦干净，含有挡水板、运水扇、油网、过滤网等前端净化部件的和排烟罩面板一样，都需要先将表面油垢铲干净，然后放在火碱水里泡，待油泥完全泡除后，再用高压水枪(清水)洗净。据经验证明，80%左右的厨房排烟不畅主要原因是油烟净化器的内置过滤网不洁堵塞。所以前端净化器的部件清洁是非常重要的
Cleaning method: Explosion proof lamps and UV lamps can be cleaned frequently with a damp cloth. For front end purification components such as water baffles, water fans, oil screens, and filter screens, just like smoke exhaust hood panels, the surface oil stains need to be removed first, and then soaked in caustic soda water. After the oil stains are completely soaked, they can be cleaned with a high-pressure water gun (water). According to experience, about 80% of kitchens have poor smoke exhaust, which is mainly due to the dirty and clogged built-in filter screen of the oil fume purifier. So it is very important to clean the components of the front-end purifier
二、排烟管道的清洗方法
2、 Cleaning methods for smoke exhaust pipes
排烟管道
Smoke exhaust duct
部件：包含主管道、防火阀、止回阀、调节阀、消音管道、软连接、弯头、三通等。
Components: including main pipeline, fire damper, check valve, regulating valve, silencing pipeline, soft connection, elbow, tee, etc.
清洗方法：油烟管道清洗是排烟口和烟罩相连处，和与烟罩平行的排油烟管道内部，这些地方必须彻底清洗。清洗管道拐弯位置，例如弯头、三通，必要时在弯头上方开口。外部油烟管道每隔一个季度清洗一次，不过一个季度只需清洁管道弯头。
Cleaning method: The key to cleaning the oil fume pipeline is the connection between the smoke exhaust outlet and the smoke hood, as well as the interior of the oil fume pipeline parallel to the smoke hood. These areas must be thoroughly cleaned. Clean the bend position of the pipeline, such as elbows and tees, and open an opening above the elbow if necessary. The external oil fume pipeline should be cleaned every other quarter, but only the pipeline elbows need to be cleaned once a quarter.
三、排烟风机/风柜的清洗方法
3、 Cleaning methods for smoke exhaust fans/cabinets
风柜
Air cabinet
部件：风机包含电机等部件，风柜就是把风机放在柜子里，包含风机和柜体。
Components: The fan includes components such as a motor, and the fan cabinet is where the fan is placed, including the fan and the cabinet body.
清洗方法：清洗时，先拆开电机或拆开电机扇叶，再用铲刀铲干净风机扇叶上的油污及风机里面的油渣，然后用除油剂清洗，洗完后再用清水冲洗干净。
Cleaning method: When cleaning, first disassemble the motor or motor fan blades, then use a shovel to clean the oil stains on the fan blades and the oil residue inside the fan, and then use a degreaser to clean. After washing, rinse thoroughly with clean water.
风机的内部和外部都要清洗，防止锈蚀。
The interior and exterior of the fan should be cleaned to prevent rusting.
四、后端油烟净化器的清洗方法
4、 Cleaning method for rear end oil fume purifier
排空油烟净化器
Drain the oil fume purifier
部件：电机和油烟处理系统（如滤料、静电处理装置、离心装置等）
Components: Motor and oil fume treatment system (such as filter material, electrostatic treatment device, centrifugal device, etc.)
清洁：按照油烟处理装置的类型进行相应的清洁工作，如更换滤料，清洁静电处理装置等。注意：在清洗酒店厨房排烟设备时，带电的设备必须提前关掉电源。
Cleaning: Perform corresponding cleaning work according to the type of oil fume treatment device, such as replacing filter materials, cleaning electrostatic treatment devices, etc. Attention: When cleaning the smoke exhaust equipment in the hotel kitchen, powered equipment must be turned off in advance.
要想排烟设备使用寿命长，还需要定期做一些日常的保养：如清洁风机、运水扇、分水扇表面污渍，保持管道通畅，保证运水箱内水质洁净，避免控水箱缺油等等。
To ensure a long service life of smoke exhaust equipment, regular daily maintenance is also necessary, such as cleaning the surface stains of fans, water transport fans, and water distribution fans, maintaining unobstructed pipelines, ensuring clean water quality in the water transport tank, and avoiding oil shortage in the control tank.
一旦发现任何反常现象，都要找到原因并及时解决。只有这样才能减少隐患，不耽误厨房的繁忙工作。
Once any abnormal phenomena are discovered, the cause must be identified and promptly resolved. Only in this way can we reduce hidden dangers and not delay the busy work of the kitchen.
This article is a friendly contribution from the kitchen smoke exhaust hood of Jinan Hotel. For more relevant knowledge, please click on: http://www.jntfgd.com Sincere attitude. We will provide you with comprehensive services. We will gradually contribute more relevant knowledge to everyone. Stay tuned
上一篇：防止镀锌风管震动和噪音要注意什么？
下一篇：通风管道主要有哪些作用领域？
